Have questions or want to discuss cycling? Join Now or Sign In to participate in the BikeRide community.


Cable on front derailleur keeps getting damaged
#1
I have a Shimano "050" front derailleur, and every few months, the cable is breaking - always at the same location at the point where it is tied to the clamp (which is held by the bolt on the derailleur).

I am using top routing, and here are the instructions as published by Shimano:
http://techdocs.shimano.com/media/techdocs/content/cycle/SI/Tourney/FrontDriveSystem/SI_6DK0B/SI_6DK0A/SI_6DK0B_En_v1_m56577569830607106.pdf

The following image shows how Shimano recommends the cable to be installed, and that's how it is on my bike.
[attachment=4875]

The problem is that when the cable is pulled (to move to the higher gears), the pulley moves up and forward, and therefore the cable gets bent at a very small radius as all the force is being made on that clamp. Therefore, the cable gets bent on every shift, and after a few hundred shifts, it breaks.

By the way I'm using Jagwire cables so they shouldn't be bad (or so I'm told).. so what can I do? Is replacing the derailleur the only option?
  Reply
#2
You could try sanding a small bevel onto the area of the clamp that really digs into the cable as it pivots. Perhaps if it spreads the bend out over at least a few millimeters it may prevent it from causing the wires to break. You wouldn't want to radically change the pivot point of the cable as it could affect the shifting. But I don't think it would hurt anything to round off that corner so it doesn't make such a sharp bend in the cable.
  Reply
#3
Thanks for the tip. I tried rounding it down using a bench grinder, and it still seems to be shifting just fine. Hopefully now the wire will last a bit longer
  Reply


Possibly Related Threads...

Forum Jump:

[-]
10 Latest Posts
Cycling industry is pricing out their ow...
Today 01:00 PM
eBikes are banned in these places!
Today 10:54 AM
Best way to thoroughly clean a chain?
Yesterday 08:52 PM
Peugeot Nouveau Folder
Yesterday 05:24 PM
The great thing about trikes
Yesterday 12:11 PM
CALLING UK CYCLISTS! - Take Action to Fu...
02-19-2025 08:25 AM
Club Rides
02-17-2025 09:24 AM
Tubeless vs. tubes: What are the pros an...
02-16-2025 07:07 PM
What are the pros and cons of clip-on pe...
02-16-2025 06:55 PM
Where to travel on a bike Bucket List.
02-16-2025 10:33 AM

[-]
Join BikeRide on Strava
Feel free to join if you are on Strava: www.strava.com/clubs/bikeridecom

[-]
Top 5 Posters This Month
no avatar 1. Flowrider
17 posts
no avatar 2. meamoantonio
15 posts
no avatar 3. enkei
14 posts
no avatar 4. GirishH
12 posts
no avatar 5. rydabent
10 posts